Login

1

General Discussion / HWH 725 Jack Issue PC2350

« on: April 19, 2023, 10:10:37 pm »

Hi everyone, so I’m traveling and just encountered an issue with a single Jack (LR) not lowering. The pump runs trying to finish with lowering spring but not happening. I am familiar with replacing parts on this in the past but this issue is not like previous. Reading the online service troubleshooting manual does not have a specific example or I haven’t found it yet.
I was searching this forum and read past subjects related to HWH and surprisingly didn’t see same issue with one Jack not dropping and or extending.
This Jack did have wire broke in past but this issue only caused the Jack to extend immediately due to sensor malfunction. I’ve checked fluid level and the wires look good. This also worked fine 2 nights ago at previous campground. I had to release valve pressure to allow spring to pull Jack back up after multiple attempts pulling down and troubleshooting.  Any suggestions welcome.  I’ll plan to call HMH tomorrow while driving East on 40 and will be sure to share the solution for others once this is figured out.
Thanks!
Rob

2

General Discussion / No AC Power - Resolved!

« on: August 11, 2019, 03:39:48 pm »

So, I just noticed no AC power when plugged in this morning.  We have a 2019 E450 2350.  All breakers confirmed on.  I have tried the following troubleshooting so far and decided to share on the forum before I start taking the bed apart to get to the connections.

1. Unplug external AC power.  Turn on Generator.  Confirmed the transfer switch worked and the generator provided power to all equipment.  Confirmed cabin batteries charged some during the generator use.  Turn off generator.
2. Start vehicle, review cabin battery status and no power from vehicle running
3. Reviewed cable connection at battery compartment and all looks tight; but per 1 and 2 that is not where the problem would be.

What am I missing, is there another breaker somewhere that may be tripped preventing AC Power?

Thanks
Rob

3

General Discussion / 2019 E450 2350 Rough Ride

« on: July 26, 2019, 03:20:48 pm »

HI everyone, so there are many nice features about the PC 2350 but the E450 chassis change is not what we expected.  Our previous PC was 2018 2100 E350 and the ride (related to bumps in the road) was much better.  I understand the E450 is build to be tougher but did not expect the ride to change this much.  The front end is terrible when you go over the slightest crack or bump in the road. Everything in the RV bangs/slams and startles you you each time you go over a bump.  This issue is causing an unpleasant driving experience. The steering is great and have a the Safety Plus stabilizer bar.  Smooth road the ride is great.  Even with Air Ride installed in the rear at 90 lbs, the RV ride is not good over any type of bump.  My budget does not afford liquid sprigs and would hope that is not the only solution.  Does anyone else have an E450 with similar problems?  Any recommendations? I read online that better shocks will not help?  I called Ford directly and did not get very far; they suggested I speak with the manufacturer.. figures.
Thanks!
Rob in Maryland